2000 Chevrolet Malibu Engine Problems
- 32
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Among these 32 stored complaint records:
- 0 indicate a crash
- 1 indicate injury
- 0 indicate fire
What owners report
- intake manifold · 7 records
- manifold gasket · 6 records
Mileage in stored records
| Band | Records |
|---|---|
| 60–100k mi | 6 |
| 30–60k mi | 4 |
| 1–30k mi | 2 |
| 100–150k mi | 2 |
| 150–400k mi | 1 |
Complaint records
Owner-submitted complaint content, presented as stored.
Engine
Tl*the contact owns a 2000 chevrolet malibu. While driving at highway speeds, the vehicle suddenly shuts off. The vehicle has not been diagnosed by the dealer. The current and failure mileages were 135,000.
ODI 10280463
Engine
I bought the car at the end of 2000 and had to replace the intake manifold gaskets at around the same time (thanksgiving) in 2001. My fuel pump went out in 2002 and my mechanic just told me the intake manifold gaskets are leaking again. He suggest to replace them soon. It cost $900 to get it fixed the first time which was not under my extended warranty plan. I just paid the car off and have to fork out another…
ODI 10219321
Caliper · Control Unit/Module · Electrical System · Emission Control · Engine · Hazard Flashing Warning Lights
Intake manifold gasket replaced three times under and outside of warranty. Hazard switch malfunctioning - almost caused accident turning signal/wiper washer switch malfunctioning premature brake wear until calipers replaced check engine light various emissions and fuel vapor leaks. *jb
ODI 10205546
Engine · Manifold/Header/Muffler/Tail Pipe
Dt*: the contact stated an odor was detected and there was fluid leaking on the ground from the engine compartment. When the contact inspected the vehicle by raising the hood, there was fluid on the engine block. The dealership determined the manifold gasket needs to be replaced. Updated 03/28/06. *jb
ODI 10150110
Engine
The incident is the failure of the water pump, a slapping noise coming from the engine, at one point the leakage of coolant, and also the oxygen sensor. All of which were taken back to the dealer to be fixed by their mechanic except the oxygen sensor. However, the car still had a problem with idling as the car was being driven away from the mechanic. My husband had to jump out of the car because of the issues, on…
1 injury
ODI 10147910
Engine
Car has had a leak for a month and when i finally got it to a car mechanic i was told that i had an intake gasket leak and that it was very common among chevrolets. The problem i was told was that the manufacture had designed a poor gasket and that once the problem was identified that they came out with a more durable gasket. This repair was quoted at $700. Why is it that if this is a common problem and that the…
ODI 10131522
Engine
The intake manifold gasket is defective on all 3.1 l gm engines like the one in my 2000 malibu. Gm dealers know that it always leaks around 70 k miles, and just keep trying to replace it. Every mechanic in the country seems to know this fact, and make about a thousand for it from each owner.
ODI 10122156
Engine
Abs light comes on intermittently, fan does not operate on speeds 1 & 2, brake rotors and pads need replaced every year, hazard/turn signal lights operate intermittently, and intake manifold gasket began leaking around 70,000 miles. The coolant is listed in the owner's manual as not needing service for 150,000 miles but it turned very acidic in less than half that time and ate the gasket causing the need for costly…
ODI 10114119
Engine · Fuel System, Gasoline
I am the owner of a chevrolet malibu. This car is very dangerous and should be recalled. The car will shut off when driving speeds of 55 or more. I have had nothing but problems since i purchased this car. First, it was the intake manifold gasket. Second, it was something wrong with the fuel system. Third, the car quit on me and my daughter when we were driving on the express way going 60 miles per hour. We could…
ODI 10090464
Engine
Oil leaked into coolant system of our 2000 chevrolet malibu requiring replacement of the intake manifold gasket and flushing out of the engine. This engine only had 40,900 miles on it. Research has shown numerous complaints for this problem on this particular gm engine (3.1 liter).
ODI 10081301
Engine
While driving at 80 mph vehicle stalled. Consumer restarted the vehicle, and was able to pull over to the shoulder. Consumer had vehicle towed to the dealer for analysis, but dealer could not resolve the problem. *ak
ODI 10047927
Engine
My 2000 chevrolet malibu (36,000 miles) recently stalled 4 times while i was driving at high speeds on the highway. On friday 10/7 i was going approximately 80 mph when the car suddenly turned off. I coasted to a stop on the shoulder. In about 5 minutes i was able to cut the car back on. At which time it resumed driving normally for about 10 miles. Then it stalled again. I towed the car into town and drove it to a…
ODI 10046782
Engine · Fuel Gauge System
Fuel gauge will not register a half tank or less. Vehicle has to have a full fuel tank. Also, without warning or cause vehicle will shut down, and will not restart. Dealership mechanic was baffled because he could not duplicate the problem. *ak
ODI 10038550
Engine
2000 malibu has died 7 times while driving dealer has replaced fuel filter and pump,radar cap ,ignition modular, ignition switch,main computer and it still dying. I have just look at all the complaint that people have and chevrolet tells me they know nothing about them.i will never buy other one. *la
ODI 10041650
Air Conditioner · Defroster/Defogger/Hvac System · Disc · Engine · Turn Signal
Air conditioner switch turns on and off. Vibration in front end when braking. Turn signals work intermitently. Ticking noise in engine until warm. Windows fog excessively. Shame on chevrolet. *ak
ODI 10032953
Electrical System · Engine
I bought this chevrolet malibu ls in 2000 and already i have the following problems: alternator is out, air compresser out, blower motor is out, battery is out they are still checking on the oil leakage. *nlm
ODI 10023136
Engine
While traveling on the highway and without prior warning the vehicle stalled. *ak
ODI 10022391
Cables · Cooling System · Engine
My car is only 3 1/2 yrs. Old, but, i'm having problems with it that i shouldn't be having. Last summer, i had to have my battery and surrounding wires & hoses replaced due to a corroded cable which had leaked acid everywhere--luckily under warranty. Now, my intake valve gasket is ruined, so antifreeze leaks out constantly and the car is perpetually on the verge of running hot. I have to constantly add antifreeze…
ODI 10025831
Electrical System · Engine
I bought this car brand new (had 4 miles on it) in august of 2000. Within a month, the a/c motor had to be replaced. Within 6 months the engine began to surge, and felt like it was going to stall whenever at a stop. During this same period of time, the brakes began pulsating, and i replaced them on my own. I have not had an issue with them since. Then this year, 2003, it completely died on me while doing 70 in rush…
ODI 10041291
Engine
Both engine mounts broke while driving 5 mph. Dealer notified, and made the repairs. Manufacturer was notified. Feel free to provide any further information.*ak
ODI 8014658
Caliper · Engine
Vehicle experienced a "ticking noise in the engine." *ph the consumer left front caliper bolt is stripped causing a vibrating/ grinding noise that radiates from the left front wheel under the driver side when the vehicle comes to a complete stop. When the dealer was contacted they stated that they could not duplicate the problem. And the consumer is trying to obtain an over all inspection of the mechanical defects…
ODI 10055573
Engine
After the vehicle was taken for an oil change engine began to make a loud knocking and ticking noise until vehicle warmed up. Manufacturer has recognized the problem ,and said that it was currently under investigation, but it was normal. Defect was in the pistons.*ak
ODI 883894
Air Conditioner · Engine · Hazard Flashing Warning Lights · Turn Signal
Hazard and signal lights malfunctions engine noise (constant squeaking or ticking) air conditioning malfunctions. *jb
ODI 10016240
Disc · Engine · Fuel Gauge System
Replaced rotors and pads10/26/2000 and02/09/2001.replaced fuel tank sending unit 03/02/2001 replacing pistons in engine 03/05/2001
ODI 741953
Engine
Vehicle experiencing excessive carbon build up on the piston rings, causing engine knocking and erratic operation. Dealer notified, and repairs were made, but problem reoccurred. *ak
ODI 872550