2001 Chevrolet Malibu Manifold/Header/Muffler/Tail Pipe Problems
- 26
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
What owners report
- intake manifold · 21 records
- manifold gasket · 14 records
- lower intake · 7 records
- gasket replaced · 5 records
- coolant light · 4 records
- intake gasket · 4 records
Mileage in stored records
| Band | Records |
|---|---|
| 30–60k mi | 12 |
| 60–100k mi | 6 |
| 100–150k mi | 1 |
| 1–30k mi | 1 |
Complaint records
Owner-submitted complaint content, presented as stored.
Manifold/Header/Muffler/Tail Pipe
I have malibu 2001 with 56000 mls on it. Today i had to change lower intake manifold gasket.$950 total...beside this a had problems with my theft system,brakes ,light hazard switch. Air conditioner ..etc. This is the my last gm car..period. *tr
ODI 10212261
Manifold/Header/Muffler/Tail Pipe
After having to refill my engine coolant on a regular basis i finally took my 2001 chevy malibu into the dealer to have it looked at. I expected a leaky hose but found out the problem was a failed intake manifold gasket causing the coolant to drain into the engine. The dealer guaranteed me that if i didn't perform the $900 repair that the engine was shot, and that the odds of saving the engine even after the repair…
ODI 10175711
Manifold/Header/Muffler/Tail Pipe
Tl*the contact owns a 2001 chevrolet malibu. The contact stated that there was an antifreeze leak in the intake manifold gasket. She took the vehicle to the dealer and they confirmed the leak. She had to place antifreeze in her vehicle every month because it would leak out constantly. She notified general motors twice. The first time, they did not respond to her via email. The second time, she spoke with them and…
ODI 10212416
Manifold/Header/Muffler/Tail Pipe
I had taken my vehicle in to get a simple oil change and was informed my vehicle has a faulty intake manifold gasket which is a very expensive repair costing any where from$ 800-$1000.00 . On my searching the internet i have found that this is one of the problems that gm cars are having over 70,000 miles. Intake manifold leaks can lead to any number of very serious, and expensive problems. While the part itself…
ODI 10181903
Manifold/Header/Muffler/Tail Pipe
Lower intake manifold replacement. Started losing antifreeze - leak on driveway. Mechanic traced the leak with dye tablets and sealant tablets -- after several months i took it chev. Dealer and they tested everything and replaced the lower intake manifold and was told this model car had manifold problems. It cost me $990. I had this work done about a year ago and thought maybe with the other malibu's having problems…
ODI 10197818
Manifold/Header/Muffler/Tail Pipe
Dt*: the contact stated while traveling 45 mph, the temperature gauge went above the normal range. The vehicle was taken to an independent repair shop, where it was determined the fuel regulator was spewing fuel onto the engine. The intake manifold seals were no longer there, causing fuel to get into the oil. The repair shop replaced the intake gasket, thermostat, timing belt, cooling fan, fuel regulator, and…
ODI 10155604
Manifold/Header/Muffler/Tail Pipe
I noticed on my 2001 chevy malibu that the coolant light was coming on so i took it to the dealership where i purchased it. He raised the hood and said i was low on coolant without even taking the lid off. He said he would have it checked out and it would be an hour or more so i stayed since i had no way of getting home. Two hours later he came out and said i had a intake manifold gasket leak, a water pump that…
ODI 10155637
Manifold/Header/Muffler/Tail Pipe
Tl*the contact owns a 2001 chevrolet malibu. While driving up a very steep incline at an unknown speed, the vehicle began to overheat. The contact managed to pull over and called a tow truck. Once the tow truck arrived, the driver placed coolant into the vehicle. The contact drove to her residence and called her local mechanic. The intake manifold gasket was repaired. On june 9, 2008, the vehicle began to overheat…
ODI 10231328
Manifold/Header/Muffler/Tail Pipe
I have had to replace my 2001 chevy malibu's manifold twice, and i have notice that i am not the only one. This is not normal wear and tear this is a manufacturer defect. *jb
ODI 10149820
Manifold/Header/Muffler/Tail Pipe
Dt: the contact stated the engine overheated due to leaking of coolant. The coolant had to be added weekly. She took the vehicle to a dealer, who determined this was a problem with the intake manifold gasket, which was replaced. *ak
ODI 10143999
Caliper · Manifold/Header/Muffler/Tail Pipe
Tl*- the contact stated that the front brakes on his 2001 chevrolet malibu (50000 failure mileage) had to be replaced every six months for the last two years. The contact also stated that antifreeze leaks into the oil. This will be the third time that the intake manifold gasket has had to be replaced. The vehicle has been taken to a mechanic six times concerning these issues. The brake and manifold problems still…
ODI 10185772
Manifold/Header/Muffler/Tail Pipe
I took my 2001 chevy malibu ls in to get the oil changed. The mechanic told me that a common problem for the gm engines of my year and others was the intake manifold gasket leaking coolant, and that if left un-fixed, the engine would eventually seize up. I was told that the material that the gaskets were made out of has since been changed, which would imply that they know it to be faulty. I contacted gm and took it…
ODI 10150075
Manifold/Header/Muffler/Tail Pipe
I had to repair a manifold intake gasket, leaking water. . I have talked to several auto repair shops and they said this is a common problem on these chevy malibus. The chevy co. Should have to do a recall on this problem. Unfair that the consumer has to pay the bill to have this fixed. Please check into forcing a recall on this please. *nm
ODI 10132586
Manifold/Header/Muffler/Tail Pipe
I have recently had to take my car to the mechanic to get fixed. It was leaking the engine coolant and the manifold gasket had to be replaced which cost over $800 to fix. Now , the check engine light is on and that will be another expense that i will have to make on a 4 year old 26,000 mile car.
ODI 10121637
Engine · Manifold/Header/Muffler/Tail Pipe
I notice that my coolant had to be refilled because the "low coolant" light was staying on in the dash. The repair shop told me they had to replace the intake manafold and i now have coolant in my engine and in my oil. This is a potential dangerous problem with the malibu. The engine could blow creating other problems. The same problem has been noted with many other malibu owners. *ak
ODI 10100059
Manifold/Header/Muffler/Tail Pipe
Vehicle would not start. Consumer had the intake gasket and intake sensor replaced. Vehilcle was in the repair shop once again. Consumer triedto contact the manufacturer. *ak
ODI 10103605
Manifold/Header/Muffler/Tail Pipe
Car has only around 21,000 miles and had to have intake manifold gasket replaced. *ak
ODI 10098479
Manifold/Header/Muffler/Tail Pipe
I own a 2001 chevrolet malibu with less than 41000 miles. Recently the intake manifold gasket failed, allowing coolant and engine oil to enter mix.*ak after doing some research, i have found that this has been an on going problem with this type of car. Chevy expects it customers to fix this problem out of their own pocket and denies any responsiblities. Again, if you investigate this matter you will find that this…
ODI 10083036
Air Conditioner · Belts And Associated Pulleys · Control Module · Cooling System · Engine · Hoses/Lines/Piping/Fittings · Manifold/Header/Muffler/Tail Pipe · Radiator Assembly
While driving home from work in 90+ degree heat my car overheated to the point where i had to have it towed in and was told by the mechanics that my coolant had been leaking and causing the car to over heat there blowing the head gasket and causing me to have to pay $1200.00+ to have another engine put it. I have heard this is a commom with the 2001 chevrolet malibus. I don't know what the repair shop done with the…
ODI 10130329
Control Module · Engine · Gasoline · Manifold/Header/Muffler/Tail Pipe
I am a single mom of two, and am frustrated that all of my savings have gone into this money pit. I have replaced the intake manifold twice, and its going out again! I have replaced the water pump, heater core which are dying, and the theft system twice. I have had a fuel leak by my engine and had it enter inside my car and its doing it again, my abs brakes only work when they want, and these are just a few of my…
ODI 10218191
Cooling System · Engine And Engine Cooling · Gas Recirculation Valve (Egr Valve) · Manifold/Header/Muffler/Tail Pipe
Dt: the contact had the egr valve, thermostat, water pump, intake gasket, and head gasket replaced. Additionally, she had the block inspected for cracks. It has been 18 months since the replacement of the aforementioned defects, and the check engine light came on again ,and there was a decrease in the amount of gas mileage. The dealer reprogrammed the computer, and informed the contact that the vehicle was running…
ODI 10143870
Manifold/Header/Muffler/Tail Pipe
Driving at hwy speed check coolant light came on added coolant took to local garage. The lower intake manifold needs to be replaced at a cost of approx. $900. It only has 44,000 miles and i have had all the required servicing done to this car.the garage tech said that they have had to replace this on several other malibu's. This must be a defective part as it should not have to replaced this soon. What can be done?…
ODI 10072325
Manifold/Header/Muffler/Tail Pipe
While driving coolant light illuminated on the dashboard. Consumer added coolant, and noticed coolant stains on the left side of engine. Dealership performed a diagnostic test which indicated that the lower intake manifold gasket was bad.*ak
ODI 10063119
Manifold/Header/Muffler/Tail Pipe
Since i had bought my 2001 malibu in october of 2003 i have had to add coolant intot he car about every other day. I finally got fed up with doin that and decided to have it pressure checked. Once i did that i found out there was a leak in the intake manifold. The company that did the pressure test also told me that they have repaired this exact part in several other cars within the last two months. Please tell me…
ODI 10050581
Manifold/Header/Muffler/Tail Pipe
LOWER INTAKE MANIFOLD GASKET LEAKING. *NLM
ODI 10016350