2008 Chevrolet Malibu Fuel/Propulsion System Problems
- 38
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
What owners report
- fuel tank · 14 records
- fuel pump · 12 records
- fuel leaking · 8 records
- engine light · 8 records
- check engine · 7 records
- failure mileage · 6 records
Mileage in stored records
| Band | Records |
|---|---|
| 100–150k mi | 13 |
| 60–100k mi | 12 |
| 30–60k mi | 6 |
| 150–400k mi | 2 |
| 1–30k mi | 1 |
Complaint records
Owner-submitted complaint content, presented as stored.
Electrical System · Exterior Lighting · Fuel/Propulsion System
Lighting not working in car, power lock not working, power truck open not working, bad suspension.
ODI 11297179
Fuel/Propulsion System
Fuel leaks/ignition fire; took vehicle to chevy dealer to have recall items fixed and inform them the fuel leak problem with regards to nhtsa campaign #13e-043 and the article of 10/01/12 siting that gm was recalling 41,000 cars sold in warm weather states including ca, because of defective plastic part might cause "fuel leakage in the presence of an ignition source may result in a fire." gm told nhtsa that it began…
ODI 11131706
Fuel/Propulsion System · Unknown Or Other
Strong gas smell from rear of vehicle (interior/exterior). Leak confirmed from fuel pump when in motion. Also, vehicle hesitates when accelerated, usually after vehicle sits for an extended period of time.
ODI 11124089
Electronic Stability Control · Engine · Fuel/Propulsion System
Takata recall, my 08 malibu will not start after driving no matter how long. I've been stranded multiple times. I bought a new starter, relay switch, ignition, switch, and paid for multiple diagnostic tests. Every mechanic sends me to the dealer ship and says they can't find the problem but believe it's the ecm. I'm taking it to the dealer today and praying this doesn't cost me another car!
ODI 11119309
Engine · Fuel/Propulsion System
Fuel tank leaking seen several chevys where recalled but my vin number is not including unable to drive care as dangerous fuel leak
ODI 11084568
Fuel/Propulsion System · Steering
We have had two issues. First broken fuel pump spilling gas on top of the fuel tank this has been an issue with this type of vehicle but not this specific vehicle. Cost to repair 400 dollars. Issue two. Bad torque sensor on electric power steering column. Causing power steering failure at will. Major safety issue as well. Chevy told me this specific part was not part of an earlier recall. Cost to fix 622 dollars at…
ODI 11066027
Engine · Fuel/Propulsion System · Steering
Engine broke down 2 weeks later they said we will give you warranty and when i refill gas the fuel sensor doesn't reach full tank and steering lost its grip the same week of purchase
ODI 11122008
Fuel/Propulsion System
Tl* the contact owns a 2008 chevrolet malibu. The contact called on behalf of his mother-in-law who stated that the fuel was leaking underneath the rear of the vehicle. The vehicle also emitted a fuel odor. The contact took the vehicle to the city chevrolet dealer in san diego, california where it was diagnosed that the fuel pump module failed and needed to be replaced. The contact was unsure if the vehicle was…
ODI 11033844
Fuel/Propulsion System
Gas leak. Gradually began to notice strong fuel order and now an actual leak.
ODI 11094128
Fuel/Propulsion System
Tl* the contact owns a 2008 chevrolet malibu. While the vehicle was stationary, the fuel pump valve sprayed fuel onto the fuel tank. While the vehicle was in the run position, the odor of fuel was present near the exhaust. A dealer and the manufacturer were not made aware of the issue. The failure mileage was approximately 150,000.
ODI 11023705
Fuel/Propulsion System
Noticed a strong fuel smell coming from the back of the car. An inlet line on the fuel pump was cracked allowing fuel to leak on the top of the tank and on the exhaust.
ODI 11012165
Fuel/Propulsion System
Gas leaking, module fuel pump & sender assembly had to be replaced, article in times paper said it was recalled because of this problem in 2012, i never received a recall notice. This could have been a very dangerous problem as the gas odor was very strong and i kept having to fill my car up with gas. Did not take it to the dealership because i did not receive a notice and wanted it fixed before someone got hurt or…
ODI 11018917
Air Bags · Fuel/Propulsion System
The air bag light comes on and it says to be serviced. Sometimes it comes on and it can stay off for long periods of time. The service air bag light can come on while the car is in motion and then turn off, sometimes it does stay on. My vehicle is giving a strong smell of fuel coming from the rear of the car. I notice it being a stronger smell after i station it after a drive. I have not seen a noticeable leak yet.…
ODI 11006661
Fuel/Propulsion System
This car has 77000 miles, and dumping fuel from top of fuel tank on to exhaust system while being driven. Fuel is also smelled after being driven.
ODI 11076773
Fuel/Propulsion System
Fuel line is cracked and leaking, it is part of the fuel pump assembly. Their are recalls regaurding similar issues on various models the same year. This vehicle should be under recall as well. I am the tech working on this vehicle and this is the second one i have seen within a year. It leaks fuel from the top of the fuel tank down the back and on the exhaust pipe. Very dangerous safety situation. I will keep the…
ODI 10947048
Electronic Stability Control · Fuel/Propulsion System
Takata recall my 2008 chevy malibu got stuck in reverse when i was backing out of a parking spot and i fixed it with zip ties but the plastic pin that holds my shifter to my transmission got stuck.
ODI 11164668
Fuel/Propulsion System
Tl* the contact owns a 2008 chevrolet malibu. The contact stated that fuel was leaking from the top of the fuel tank. The vehicle was taken to the dealer where it was diagnosed that the fuel pump assembly needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 109,586.
ODI 10920229
Body · Fuel/Propulsion System
Purchased a used 2008 chevrolet malibu. Very shortly after i could notice a strong odor of gas coming from the rear of the vehicle after driving it. I took it to a mechanic who removed the fuel tank and discovered that a plastic feed line on top of the fuel pump module had a severe leak. I contacted gm in regard to the fact that this specific issue has been recalled on the exact same year, make, and model as my…
ODI 10845910
Fuel/Propulsion System
Tl* the contact owns a 2008 chevrolet malibu. The contact stated that there was an abnormal odor of fuel coming from the rear of the vehicle. The vehicle was taken to the dealer to be inspected. The contact was informed that the fuel tank was fractured and a rubber seal on the fuel tank needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure…
ODI 10816515
Fuel/Propulsion System
Upon entering the back passenger side seat of my daughter's car, i noticed a strong fuel smell. Upon returning to the car, i noticed the strong fuel smell outside the car, too. When we started looking around under the car, we saw fuel leaking onto the parking lot. The car has 68,000 miles. The independent garage she took it to said the plastic part of the fuel line was leaking and replaced the fuel line assembly and…
ODI 10809890
Air Bags · Electrical System · Fuel/Propulsion System
My gas tank started leaking for no reason (no wear and tear-every mechanic said that is almost unheard of), my power windows and lock stopped working 2 years after purchase and was told that i had to pay almost $300 to fix each motor for the door locks and windows, the service airbag light has been on for more than a year, my ac also have issues; the sensor and thermostat has been changed 6 times within the last 4…
ODI 10783143
Air Bags · Electrical System · Fuel/Propulsion System
Electrical and module problems safety hazards with traction control. Tc on when it should not be. Fuel system problems. Car powers off during driving. Gm refused repair without charging 120 to look at. Had to disconnect fuses and had to pull actuators pressure. Sensors fuel and electrical. Door latches going up and down even when car is off. Cannot drive highway. Gm refused vehicle from repair or compensation.
ODI 10774201
Fuel/Propulsion System
Tl* the contact owns a 2008 chevrolet malibu. The contact stated that while driving at various speeds, the vehicle emitted a fuel odor. The failure recurred on numerous occasions. The vehicle was taken to an independent mechanic where it was diagnosed that the vehicle was leaking fuel from the fuel tank and needed to be replaced. The vehicle was not repaired. The approximate failure mileage was 140,000.
ODI 10779780
Fuel/Propulsion System
Car leaking fuel from fuel tank. Just notice gas smell for about a year now. Kept getting worse, then check engine came on around december 2015, about a fuel pressure sensor. Finally looked under the car and fuel is coming out of the top of the fuel tank. Actually see fuel leaking from the tank, and dirt stains were fuel has been leaking
ODI 10824192
Air Bags · Fuel/Propulsion System · Wheels
Went i bought the car had been give problem now the car smell like is leaking gas and the airbag system turn on my front wheel crack went i turn right or left i took to the dealership they said they fix the problem but still does same thing they don't help anything make me waste my time my car i peace [xxx] i wanted my all my money back. Information redacted pursuant to the freedom of information act (foia), 5…
ODI 10846224